Sep 20, 2009 I'll tell ya what a diesel mechanic told me. Insurance decided in 2004 since it was a 94 model to total it even though really no damage. Now that kids need a car seat until they graduate nowadays, not being able to open a door to the back makes this a less workable family vehicle than in years past. If the panel is not visible, check for a removable compartment door or trim panel which may be used on later models to hide the block. Its purpose is to supply power to the fuel solenoid, which allows or blocks fuel flow to the injection pump. The rear-wheel drive regular cab light-duty 2500 carried a maximum payload of 2,848 pounds and towed up to 10,000 pounds. If the solenoid will not operate, replace the shutdown solenoid.
Regular cab, light-duty models had a length of 212. Four-wheel drive models with the naturally aspirated engine rated 15 mpg highway and 20 mpg city with the manual transmission and 15 mpg city and 18 mpg highway with the automatic transmission. Set up for a fifth wheel hitch. Going to have the job done now. You are probably right about the fuel pump but your best bet would be to pick up a copy of Haynes Diesel Engine Repair Manual, part 10330 first.
Was just checked out by a mechanic and they installed the following - New Brakes, New Brake Lines, New Rotors and Drums, Calipers, 2 New Batteries, New Oil Cooler Lines, and Oil Pressure Switch. This truck has always been taken care of. When power is supplied to the fuel solenoid, fuel flows to the injection pump and the engine is allowed to run. Chevy offered air-conditioning, cruise control, power windows and doors, a cassette player and a tilt steering wheel as upgrades. Its only 2-wheel drive Primary Use: Utility towing boats, transporting cargo, etc. Starts right up with no issues. It has an excellent diagnostic and repair section as well as testing procedures and repairs for these engines.
I love this truck but It just sitting around since I work out of town and have a company car. Going to have the job done now. I had the back brakes done last year. Common problems with the 6. Has gooseneck plate mounted in bed, and has towing package. Unlike the earlier engine, the 6.
I changed the fuel sending unit and that seemed to help a little, but now while driving it will shut down, and it's hard to start. The fuse block should be visible from underneath the steering column, near the pedal bracket. If you have any questions call or text me at 4846263705 I will answer any questions or send more pictures. The carpet has a plastic liner that covers the entire inside and is practically brand new underneath it. Offered as high as 440 lb-ft 1,800 rpm. Primary Use: Commuting to work. Please let me know if you have any questions.
Peak Torque: Introduced at 360 lb-ft 1,700 rpm. I do anyway as long as you have two good batteries the truck will start up first crank!! All models of the 1994 2500 trucks came with a standard five-speed manual transmission that buyers could upgrade to a four-speed automatic with overdrive. The Ac and heater work but the interior has a saggy head liner with driver seat is a bit worn. When power is cut from the fuel solenoid, fuel flow abruptly stops and the engine will stall. Towing upgrades consisted of front tow hooks, a trailer hitch and a wiring harness.
Chevy's turbocharged V-8 generated 190 horsepower and 385 foot-pounds of torque. I have a 1994 chevy truck 2500 6. All regular cab models sat three on a front bench. This truck is Diesel and has a 6. The bench seat lets the ladys slide right up next ta me. Posted on Jun 09, 2009 If your filter hasn't been changed recently then by all means do itand see if that helps. I changed the fuel sending unit and that seemed to help a little, but now while driving it will shut down, and it's hard to start.
Has some dents and where an old tire blew out messed it up a bit. Not sure if drivetrain is stock or not. Insulating washers on the terminal studs. . It seems that the new low sulfur diesel being sold now wears the seals out on the older pumps. Connect a jumper wire between solenoid ground connector and ground.
In 1994, Chevy offered two 6. Chevy offered rear- and four-wheel drive heavy-duty versions of the 2500 with a regular or extended cab and an 8-foot bed. A rear-wheel drive extended cab light-duty 2500 hauled a max payload of 2,657 pounds and had a maximum towing capacity of 10,000 pounds. A rear-wheel drive non-turbo delivered an estimated 17 mpg city and 22 mpg highway with the manual transmission and 15 mpg city and 20 mpg highway with the automatic transmission. Engine Weight: ~ 750 lbs Max Engine Speed: 3,400 rpm Peak Horsepower: Introduced at 180 hp 3,400 rpm. This body style will be classic in a few years. Wish I Had The Mopney To Dump Into It.
I change mine twice a year, spring and fall. Overheating is also an issue with the 6. This truck is in great shape for its age. The fuse is located under the instrument panel to the left of the steering column. The extended cab models sat six, split between front and rear benches. Exterior options included side body moldings, a chrome grille, a rear-step bumper and a bed liner.